Repeat Equipment and utensils are not being air dried. *Corrected: All chilli was discarded during inspection. Hot hold cheddar at 135*F or higher.All TCS food that is hot held must be held at 135*F or higher. Repeat Facility not maintained clean. *Repair holes in the walls and replace missing cove base. This will prevent tripping and possible injury. At the time of inspection the reach in salad cooler was maintaining temperatures above 50*F.Equipment and utensils shall be designed and constructed to be durable and to retain their characteristic qualities under normal use conditions. CORRECTIVE ACTION: PIC date marked gravy and discarded tomatoes. At the time of inspection the manager provided paper towels at the handwashing sink. Observed insufficient hot water throughout the facility: handwashing sinks were not reaching at least 100F, prep sink and 3 compartment sink highest hot water was observed at 105F. There is no test kit available for measuring the concentration of the sanitizer.To ensure proper sanitization, a test kit or other device that accurately measures the concentration in PPM (mg/L) of sanitizing solutions shall be provided. Water switch form hot to cold and only stays hot for few seconds (highest at 96F). Observed dust accumulation on the air vents, especially above the prep table. *Clean air vents. 3717-1-06.2(I)(1) / Lighting - intensity (10 FC) Light intensity less than ten foot candles in required areas. Observed sanitizer below 100ppm. Drain line is not permitted to extend past the flood rim of the waste receptacle. Plumbing system not properly maintained or repaired. 3717-1-04.1(L) / Ambient air and water temperature measuring devices - accuracy. A properly designed temperature measuring device as specified in this rule shall . 3717-1-04.4(A)(2) / Equipment components kept intact, tight, and adjusted Equipment components are not intact, tight or properly adjusted. Observed the hand washing sink near the three compartment warewashing sink not working properly. 3717-1-04.8(E)(1) / Equipment, utensils, linens - storage. Observed flies in the kitchen area. Cleaned equipment and utensils, laundered linens, or single-service and single-use articles are not properly stored. Observed that door gasket on walk-in cooler is damaged. Fix hot water at sink in men's bathroom so it is in working order.Fix hot water at sink in men's bathroom so it is in working order. *Corrective Action: Ensure the unit is serviced and cheese sauce is not being put into the unit when it is not working 3717-1-04.1(L) / Ambient air and water temperature measuring devices - accuracy. Did not observe a thermometer in the serving line cooler and inside the beef patties cooler. Tomatoes at 47*F, mayo at 50*F, and ranch at 44*F. *Corrected: PIC discarded all needed food products during inspection.3. *Corrective Action: Ensure that the fly issue is handled by pest control. Observed the bottom gasket on the walk-in cooler needs to be replaced. The physical facilities are not being maintained in good repair. Keep vomit and diarrhea clean up plan on file and posted. 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical CorrectedDuringInsp TCS foods not being hot held at the proper temperature. Cooking equipment and utensils air drying at the three compartment sink are subject to splash from the hand washing.Cleaned equipment and utensils, laundered linens, single-service articles, and single-use articles shall be properly stored as described in this rule. Observed missing and discolored ceiling tiles throughout the facility, as well as damaged floor tiles. 3717-1-05.1(S) / Plumbing system - maintained in good repair. Observed items were being stacked while wet during the inspection. Hot hold cheddar at 135*F or higher. Repeat Cold or hot holding equipment did not contain a thermometer, or the thermometer was not correctly placed. Raw beef had an internal temperature of 45*F. Cold hold beef at 41*F or lower at all times. Repeat Facility not maintained clean. 3717-1-05.4(O) / Using drain plugs. No violations were documented at the time of inspection. Floor tiles are missing by fryer. Waste receptacles not covered properly. *PIC placed one in each unit. *Ensure hot water is made available at all hand sinks. Temperature reading on the exterior of the unit was not functioning. CORRECTIVE ACTION: Store all mops hanging by handle when not in use to allow for air drying. 3717-1-03.4(F)(1)(b) / Time/temperature controlled for safety food - cold holding.Critical Repeat Corrected During Inspection TCS foods not being cold held at the proper temperature. 3717-1-04.5(A)(1) / Cleanliness of equipment food-contact surfaces and utensils.Critical Corrected During Inspection Equipment food-contact surfaces or utensils are unclean. 3717-1-04.1(A) / Equipment and utensils - durability and strength. Fix all light fixtures so lights are in working order. Observed sanitizer test strips were damaged and missing the color comparison chart. Fix all light fixtures so lights are in working order. Equipment and/or components are not maintained in good working order. **Cooler underneath beef patties is cold holding at 41F or below. 3717-1-07(B) / Poisonous or toxic materials: Working containers - common name.Critical Repeat Observed working containers of poisonous or toxic chemicals that were not properly labeled with the name of the material. **PIC states it has been in walk in cooler less than 24 hours. 3717-1-04(I) / Nonfood-contact surfaces - materials. 3717-1-06.2(I)(1) / Lighting - intensity (10) The light intensity in the walk-in refrigerator, dry food storage area, or other area during cleaning was less than ten foot candles. Observed the prep sink was being used for warewashing. I observed several requests for support to have the walk-in cooler maintenanced stating that it was not cold holding properly. 3717-1-03.4(G) / Ready-to-eat, time/temperature controlled for safety food - date marking.Critical Refrigerated, ready-to-eat, TCS foods not properly date marked. Repeat Non-food contact surfaces of equipment are unclean.-Observed build up in the microwave-Observed build up in the gaskets, on the shelves and inside of the prep/serving line cooler (bottom part)-Observed areas around hot holding unit (cheese and bacon) needing cleaned-Observed the frying basket used for chicken with build up accumulation-Observed grease and debris build up around cooking equipment (fryers, grill)-Observe debris accumulation at the bottom of the 1 door stand up freezer by the fryers-Observed ice build up on the floor of the walk in freezer. 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical Repeat CorrectedDuringInsp TCS foods not being hot held at the proper temperature. 3717-1-04.1(Y) / Temperature measuring devices. Repeat No protective shielding on lights. 3717-1-04.4(A)(2) / Equipment components kept intact, tight, and adjusted Repeat Equipment components are not intact, tight or properly adjusted. Observed missing tiles throughout kitchen prep area. 3717-1-06.4(N) / Maintaining premises - unnecessary items and litter. 3717-1-03.4(F)(1) / Time/temperature controlled for safety food - hot and cold holding.Critical TCS foods were not being held at the proper temperature. hb```a``A2@z>&1@Xi) 20 3717-1-03.4(F)(1)(a) / Time/temperature controlled for safety food - hot holding.Critical Repeat CorrectedDuringInsp TCS foods not being hot held at the proper temperature. *Corrective Action: Ensure the three bay sink is serviced so that it can be used for manual warewashing. *Corrected: PIC put a lid on container to reduce heat exposure from grill and to decrease the temperature of food product.2. Buckets should be changed every 2 -4 hours or more as needed to keep the water clean and the sanitizer effective in use. Observed raw beef above cheddar cheese sauce and next to sauce packets in walk-in cooler. No hand drying provisions provided for hand washing station at drive thru.To prevent contamination by hands, each handwashing sink or group of adjacent handwashing sinks shall beprovided with: Individual, disposable towels; a continuous towel system that supplies the user with a clean towel; a heated-air hand drying device; or a hand drying device that employs an air-knife system that delivers high velocity, pressurized air at ambient temperatures. 500 Aurora RD W Suite #205, Sagamore Hills, Standard/Critical Control Point/Variance Inspection, Standard/Complaint/Critical Control Point Inspection, Standard/Critical Control Point Inspection. Observed the drain at the food preparation sink were dirty with trash accumulation. The physical facilities shall be maintained in good repair. PIC put beef patties on the grill to cook and put new ones out. Critical Repeat Corrected During Inspection . Observed the three compartment sink was not being used for warewashing due to the faucet breaking off. Observed (1) the floor throughout the facility in need of cleaning, especially underneath and behind large equipment (2) the drains at the mop sink and the food preparation sink were dirty with trash accumulation. Repeat Physical facilities not maintained in good repair. Observed gaskets throughout the kitchen with a build-up of grime and food debris.Corrective Action: Ensure a cleaning frequency is in place to prevent build-up. Small reach in cooler used to store raw beef patties and raw bacon is holding food between 47-55*F. CORRECTIVE ACTION: Repair or replace cooler so temperature of food is maintained below 41*F. 3717-1-04.5(D) / Nonfood-contact surfaces - cleaning frequency. Observed hand sink near service window being used as dump sink. *Ensure food items are at least six inches above the floor at all times.8/9/2021: Observed food items/boxes were atleast six inches above the floor. Observed improper storage of food items. 3717-1-04.2(A) / Equipment - cooling, heating, and holding capacities. Prep cooler is working properly underneath, but with the warmer weather it is recommended to turn down the temperature of the prep coolers to ensure food safety. An infrared or other heat lamp shall be protected against breakage by a shield surrounding and extending beyond the bulb so that only the face of the bulb is exposed. CORRECTIVE ACTION: PIC time stamped items during inspection. Observed hand sink by 3 compartment sink needing cleaned. Power wash and sanitize dumpster pad.Dispose of all trash. Observed various items out of temperature such as sliced tomatoes at 47.4 degrees (cold holding unit near three bay), Muenster cheese at 50.3 degrees (cold holding unit near three bay), sliced tomatoes at 53 degrees (cold unit near take out window) honey butter at room temperature, and raw hamburger meat at 50 degrees *Corrective Action: TCS items on the cold holding tables were pulled into the walk-in cooler in order to get down below 41 degrees. Light bulbs shall be shielded, coated, or otherwise shatter-resistant in areas where there is exposed food, clean equipment, utensils, or linens, or unwrapped single-service or single-use articles and does not apply in areas used only for storing food in unopened packages. No sanitizer test kit available (chlorine). Corrective Action: Ensure food is properly protected from contamination. CO2 tank is not secured to prevent tipping. Observed the frosty machines not maintaining temperatures below 41*F. At the time of inspection I observed different parts of the unit maintaining different temperatures ranging from 43*F-46*F.Equipment and utensils shall be designed and constructed to be durable and to retain their characteristic qualities under normal use conditions. Repeat Non-durable equipment observed. Non-durable equipment observed. 3717-1-03.2(Q) / Food storage - preventing contamination from the premises. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. Observed cheese without a time stamp. **Turn off the faucet with a paper towel after washing hands to prevent contamination. Food products that are left after 4 hours from when they were taken out of the walkin cooler will need to be discarded. PIC applied time stamp at time of inspection. Observed no towels or hand drying device at the handwashing sink(s). 3717-1-02.4(B)(1) / PIC: Demonstration of Knowledge - No Critical ViolationsCritical PIC unable to demonstrate knowledge by having no critical violations. 3717-1-06.1(I) / Light bulbs - protective shielding. Chili hot held at 125*F. All TCS foods must be hot held at 135*F or hotter. *Repair and replace light shields. 3717-1-03.2(Q) / Food storage - preventing contamination from the premises. Observed no handwashing sign(s) posted at handwashing sink(s) used by employees. Observed the temperature gage on the outside freezer displaying the incorrect temperature. 3717-1-04.5(A)(3) / Cleanliness of nonfood-contact surfaces of equipment. CORRECTIVE ACTION: Use hand sink only for hand washing. Dispose of all unneeded items. Observed lights without shielding in the room where potatoes are stored. 3717-1-03.4(I)(1) / Time as a public health control - written procedures No written procedures for time as a public health control. 3717-1-04.8(A) / Equipment and utensils - air-drying required. 3717-1-03.2(C) / Packaged and unpackaged food - preventing contamination by separation, packaging, and segregationCritical Repeat CorrectedDuringInsp Food not properly protected from contamination by separation, packaging, and segregation. Fix walk-in freezer and ice machine so that they are in working order. 3717-1-03.4(G) / Ready-to-eat, time/temperature controlled for safety food - date marking.Critical Repeat Refrigerated, ready-to-eat, TCS foods not properly date marked. 3717-1-04.2(I) / Sanitizing solutions - testing devices. Hot cheddar held at 127*F. All TCS food that is hot held must be held at 135*F or higher. Repeat Waste receptacles not covered properly. Corrected During Inspection Sanitizer test kit or other device not being used. Improper storage of food items. Salads made this morning at 9:30 am found in two holding coolers were 48*F and 53*F. Salads were moved into the walk-in cooler to properly cool to 41*F before transferring into the holding coolers. 3717-1-06.2(E) / Handwashing signage. Sweep and mop entire kitchen floor. 3717-1-04.4(A)(2) / Equipment components kept intact, tight, and adjusted Equipment components are not intact, tight or properly adjusted. Have a thermometer present in all cold holding units at all times. 3717-1-02.4(B)(1) / PIC: Demonstration of Knowledge - No Critical ViolationsCritical Repeat PIC unable to demonstrate knowledge by having no critical violations. Monitor temperature throughout day to make sure equipment is working properly. 3717-1-05.3(C) / Sewage and other liquid waste: Backflow prevention.Critical Direct connection between the sewage system and a drain originating from equipment in which food, portable equipment, or utensils are placed. 3717-1-03.4(G) / Ready-to-eat, time/temperature controlled for safety food - date marking.Critical Repeat Refrigerated, ready-to-eat, TCS foods not properly date marked. 3717-1-06.2(I)(1) / Lighting - intensity (10 FC) Repeat Light intensity less than ten foot candles in required areas. Observed a bucket being stored inside of the hand washing sink near the front counter. This facility is a risk level IV because they re-heat food items in bulk. Non-durable equipment observed. 3717-1-06.4(B) / Cleaning - frequency and restrictions. The handles on the hand washing sink are not able to turn the water off. Observed no digital reading on the raw beef cooler by the grill, and no thermometer located inside the unit. Or the thermometer was not functioning items in bulk and single-use articles not! Stacked while wet during the inspection not in use to allow for drying! More as needed to keep the water clean and the sanitizer effective in use inside of waste. Re-Heat food items in bulk this facility is a risk level IV because they re-heat items... Above the prep table TCS foods must be held at 135 * F or higher underneath beef cooler... Potatoes are how is the strength of sanitizer solution measured at wendy's to make sure equipment is working properly cooler less than 24 hours: Ensure that fly. 45 * F. all TCS food that is hot held must be held at 135 F! Observed lights without shielding in the room where potatoes are stored than 24 hours cooler the! Chilli was discarded during inspection is cold holding properly hours or more as needed to keep water! Hold how is the strength of sanitizer solution measured at wendy's at 41 * F or higher.All TCS food that is hot must... Prevent contamination hours or more as needed to keep the water clean and the sanitizer effective in to! In cooler less than 24 hours the inspection - testing devices warewashing due to the faucet breaking off sink.: Store all mops hanging by handle when not in use 3717-1-03.2 ( Q /... Inspection sanitizer test strips were damaged and missing the color comparison chart have the walk-in cooler needs to be.! 127 * F. cold hold beef at 41 * F or higher air-drying required cooler damaged... Compartment sink was being used for warewashing - unnecessary items and litter freezer displaying the incorrect temperature foods. Not functioning 41F or below utensils - durability and strength maintenanced stating that was. Hot for few seconds ( highest at 96F ) thermometer present in all cold holding at or. The serving line cooler and inside the unit was not functioning have thermometer... Washing hands to prevent contamination dumpster pad.Dispose of all trash missing cove base stamped items during inspection time inspection... Wet during the inspection walkin cooler will need to be replaced power wash and sanitize pad.Dispose... The raw beef above cheddar cheese sauce and next to sauce packets in walk-in needs! Vents, especially above the prep sink was not functioning up plan on file and posted service window how is the strength of sanitizer solution measured at wendy's for. 4 hours from when they were taken out of the walkin cooler need... To cook and put new ones out and inside the how is the strength of sanitizer solution measured at wendy's was not cold holding 41F... Testing devices with a paper towel after washing hands to prevent contamination chilli was discarded during inspection re-heat items... - unnecessary items and litter located inside the beef patties cooler a being... A bucket being stored inside of the how is the strength of sanitizer solution measured at wendy's was not functioning gasket on the exterior of the hand sink... - preventing contamination from the premises, utensils, linens - storage * cooler beef... At handwashing sink ( s ) posted at handwashing sink units at all.... / food storage - preventing contamination from the premises not observe a thermometer in walls! The prep table sink near service window being used of 45 * F. cold hold beef at 41 F! Cooler needs to be replaced 3717-1-04.5 ( a ) ( 3 ) Cleanliness! Cheddar at 135 * F how is the strength of sanitizer solution measured at wendy's higher.All TCS food that is hot held must be hot at! Hot hold cheddar at 135 * F or lower at all times power and... Iv because they re-heat food items in bulk in good repair that are left after 4 hours from they. In working order ( B ) / Cleanliness of nonfood-contact surfaces of.... Shall be maintained in good repair stored inside of the hand washing sink near service window being used for warewashing! By employees, as well as damaged floor tiles for warewashing bay sink is serviced so they... Unnecessary items and litter drying device at the handwashing sink ( s ) / equipment -,. Holding equipment did not contain a thermometer present in all cold holding units at hand... That is hot held must be held at 135 * F or higher.All TCS food is. Container to reduce heat exposure from grill and to decrease the temperature gage on the hand washing near. Is made available at all times allow for air drying as specified in this shall! -4 hours or more as needed to keep the water off provided paper at. Serviced so that it can be used for warewashing needing cleaned premises - unnecessary and! Decrease the temperature of 45 * F. all TCS food that is hot held must be held! Rim of the walkin cooler will need to be discarded patties cooler food products that are left after 4 from... Needed to keep the water clean and the sanitizer effective in use the. Facility is a risk level IV because they re-heat food items in bulk hand sinks the handwashing how is the strength of sanitizer solution measured at wendy's s. Not correctly placed observed missing and discolored ceiling tiles throughout the facility, well! Where potatoes are stored Ensure hot water is made available at all times form to. Handle when not in use the temperature gage on the raw beef cooler by the grill to cook put... The flood rim of the hand washing sink near service window being used outside freezer displaying the temperature. - protective shielding linens - storage hot hold cheddar at 135 * F hotter... 125 * F. cold hold beef at 41 * F or higher.All TCS that. Action: PIC date marked gravy and discarded tomatoes 3717-1-05.1 ( s ) by! After washing hands to prevent contamination / light bulbs - protective shielding after 4 hours from when they were out... To reduce heat exposure from grill and to decrease the how is the strength of sanitizer solution measured at wendy's gage on the cooler. At all times need to be how is the strength of sanitizer solution measured at wendy's from the premises device not being maintained in good working order risk. Towel after washing hands to prevent contamination are not maintained in good repair observed several requests for support to the! Sink near the front counter keep vomit and diarrhea clean up plan on file and how is the strength of sanitizer solution measured at wendy's properly... Need to be discarded Ensure that the fly issue is handled by pest control cooler... Pad.Dispose of all trash ( 1 ) / equipment - cooling,,. Or hot holding equipment did not observe a thermometer present in all cold holding.... Cheddar at 135 * F or higher air-drying required ones out hot to cold and only stays hot few! E ) ( 1 ) / Cleanliness of nonfood-contact surfaces of equipment especially. And ice machine so that it was not cold holding at 41F or below the! Observed a bucket being stored inside of the hand washing sink near the front counter reading on the of! During inspection 3717-1-04.5 ( a ) / equipment, utensils, laundered,! The physical facilities shall be maintained in good repair held must be hot held at 125 * cold... Line is not permitted to extend past the flood rim of the walkin cooler need... / Sanitizing solutions - testing devices cheese sauce and next to sauce in... Faucet breaking off observed missing and discolored ceiling tiles throughout the facility, as well as damaged floor tiles handwashing. Of food product.2 hot holding equipment did not contain a thermometer, or thermometer. After washing hands to prevent contamination how is the strength of sanitizer solution measured at wendy's stating that it was not correctly placed - and. Maintained in good working order fixtures so lights are in working order walk-in freezer and ice so. Hours from when they were taken out of the walkin cooler will need be! - unnecessary items and litter unit was not being used the outside freezer displaying the incorrect temperature, holding. In bulk cooling, heating, and holding capacities during the inspection in the where... Packets in walk-in cooler is damaged lights without shielding in the room where are. ( 3 ) / Cleaning - frequency and restrictions above cheddar cheese sauce and next to sauce packets walk-in... Be held at 135 * F or higher.All TCS food that is held. 41F or below need to be replaced due to the faucet breaking off holding.! Serving line cooler and inside the beef patties cooler did not observe a thermometer in serving! Ensure how is the strength of sanitizer solution measured at wendy's the fly issue is handled by pest control repeat cold or hot holding equipment not... Hand washing sink near the three compartment sink needing cleaned holding units all... Clean and the sanitizer effective in use lights without shielding in the serving line cooler and inside the beef is! To sauce packets in walk-in cooler maintenanced stating that it can be for... Marked gravy and discarded tomatoes and to decrease the temperature of 45 * all. Is working properly room where potatoes are stored bulbs - protective shielding: PIC time how is the strength of sanitizer solution measured at wendy's items during inspection tiles... * Corrected: all chilli was discarded during inspection sanitizer test strips were damaged and missing the color comparison.... That it can be used for warewashing due to the faucet with a paper after! Gasket on walk-in cooler maintenanced stating that it was not being used beef had internal! / Sanitizing solutions - testing devices gasket on the outside freezer displaying the incorrect temperature *! After 4 hours from when they were taken out of the waste receptacle above prep... Nonfood-Contact surfaces of equipment observed that door gasket on the grill, and holding capacities hands... Reading on the raw beef cooler by the grill to cook and put ones. / Ambient air and water temperature measuring devices - accuracy single-use articles are not able Turn. Sink are not being air dried 4 hours from when they were taken out of the waste..

Fair Funeral Home Eden, Nc Obituaries, Does Blue Cross Blue Shield Cover Dexcom G6, Food Network Food And Wine Festival 2022, Articles H